Hostname: page-component-7c8c6479df-24hb2 Total loading time: 0 Render date: 2024-03-19T10:47:13.352Z Has data issue: false hasContentIssue false

Stiff Polyimides: Chain Orientation And Anisotropy Of The Optical And Dielectric Properties Of Thin Films

Published online by Cambridge University Press:  15 February 2011

D. Boese
Affiliation:
IBM Almaden Research Center, 650 Harry Road, San Jose, California 95120
S. Herminghaus
Affiliation:
IBM Almaden Research Center, 650 Harry Road, San Jose, California 95120
D. Y. Yoon
Affiliation:
IBM Almaden Research Center, 650 Harry Road, San Jose, California 95120
J. D. Swalen
Affiliation:
IBM Almaden Research Center, 650 Harry Road, San Jose, California 95120
J. F. Rabolt
Affiliation:
IBM Almaden Research Center, 650 Harry Road, San Jose, California 95120
Get access

Abstract

Thin films of poly(p-phenylene biphenyltetracarboximide), prepared by thermal imidization of the precursor poly(amic acid) on substrates, have been investigated by optical waveguide, UV-visible, infrared (IR), and dielectric spectroscopies. The polyimide films exhibit an extraordinarily large anisotropy in the refractive indices with the in-plane index n = 1.852 and the out-of-plane index n = 1.612 at 632.8 nm wavelength, indicating a strong preference of polymer chains to orient along the film plane. No discernible effect of the film thickness on this optical anisotropy is found in the range of ca. 0.4 μm to 7.8 μm in thickness. The frequency dispersion of the in-plane refractive index to 1.06 μm wavelength is consistent with the results calculated by the Lorentz-Lorenz equation from the UV-visible spectrum. The contribution from the entire IR range from 7000 to 200 cm,−1 computed by the Spitzer-Kleinmann dispersion relations from the measured spectra, adds ca. 0.07 to the in-plane refractive index n. Approximately the same increase is assumed for the out-of-plane index n, based on the tilt-angle dependent IR results. Application of the Maxwell relation leads to the out-of-plane dielectric constant ε≃2.8 at ca. 1013 Hz, as compared with the measured value of ca. 3.0 at 106 Hz. Assuming this small difference to remain the same for the in-plane dielectric constants ε, we obtain a a very large anisotropy in the dielectric properties of these polyimide films with the estimated in-plane dielectric constant ε≃3.5 at ca. 1013 Hz, and ε.≃3.7 at 106 Hz.

Type
Research Article
Copyright
Copyright © Materials Research Society 1991

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1. Sroog, C.E.,. J. Polym. Sci.: Macromol. Rev. 11, 161 (1976).Google Scholar
2. Mittal, K.L., Polyimides: Synthesis, Characterization and Applications, Vol. I & II, (Plenum Press, New York, 1984).CrossRefGoogle Scholar
3. Jensen, R.J. and Lai, J. H., in Polymers for Electronic Applications, Lai, J. H., Ed. (CRC Press, Boca Raton, 1989).Google Scholar
4. Jensen, R.J., in Polymers for High Technologies, Electronics and Photonics, Bowden, M.J. and Turner, S.R., Eds. (ACS, Washington, D.C., 1987).Google Scholar
5. Numata, S. and Kinjo, N., Polym. Eng. Sci. 28, 906 (1988).CrossRefGoogle Scholar
6. Ree, M., Yoon, D.Y., Depero, L.E. and Parrish, W., submitted to:. J. Polyin. Sci., Polym. Phys. Ed.Google Scholar
7. Russell, T.P., Gugger, H., Swalen, J.D. J. Polym. Sci., Polym. Phys. Ed. 21, 1745 (1983).Google Scholar
8. Takahashi, N., Yoon, D.Y. and Parrish, W., Macromolecules 17, 2583 (1984).Google Scholar
9. Swalen, J.D.,. J. Molec. Electron. 2, 155 (1986), and references thereinGoogle Scholar
10. Herminghaus, S., Bóese, D., Yoon, D.Y. and Smith, B.A.,. J. App. Phys, Viii. t, in press.Google Scholar
11. Swalen, J. D., Santo, R., Take, M., and Fischer, J., IBM. J. Res. Dev. 21, 168 (1977).CrossRefGoogle Scholar
12. Prest, W.M. Jr., and Luca, D.J., J. Appl. Phys., 51, 5170 (1980).CrossRefGoogle Scholar
13. Castellano, I.A. and Harrison, K.J., in The Physics and Chemistry of Liquid Crystal Devices, Sprokel, G.J., Ed. (Plenum Press, New York, 1980).Google Scholar
14. Pacansky, J., England, C. and Waltman, R.J., .J. Poly. Sci., Polym. Phys. Ed. 25, 901 (1987).Google Scholar
15. Snyder, R.W., Sheen, C.W. and Painter, P.C., Appl. Spectrosc. 42, 503 (1988).CrossRefGoogle Scholar