Hostname: page-component-7c8c6479df-995ml Total loading time: 0 Render date: 2024-03-28T20:54:35.541Z Has data issue: false hasContentIssue false

Drag and lift forces on a counter-rotating cylinder in rotating flow

Published online by Cambridge University Press:  12 October 2010

CHAO SUN*
Affiliation:
Physics of Fluids Group, Faculty of Science and Technology, J. M. Burgers Centre for Fluid Dynamics, MESA+ and Impact Institutes, University of Twente, 7500 AE, Enschede, The Netherlands
TOM MULLIN
Affiliation:
Manchester Centre for Nonlinear Dynamics, Department of Physics and Astronomy, University of Manchester, Oxford Road, Manchester M13 9PL, UK
LEEN VAN WIJNGAARDEN
Affiliation:
Physics of Fluids Group, Faculty of Science and Technology, J. M. Burgers Centre for Fluid Dynamics, MESA+ and Impact Institutes, University of Twente, 7500 AE, Enschede, The Netherlands
DETLEF LOHSE
Affiliation:
Physics of Fluids Group, Faculty of Science and Technology, J. M. Burgers Centre for Fluid Dynamics, MESA+ and Impact Institutes, University of Twente, 7500 AE, Enschede, The Netherlands
*
Email address for correspondence: c.sun@tnw.utwente.nl

Abstract

Results are reported of an experimental investigation into the motion of a heavy cylinder free to move inside a water-filled drum rotating around its horizontal axis. The cylinder is observed to either co-rotate or, counter-intuitively, counter-rotate with respect to the rotating drum. The flow was measured with particle image velocimetry, and it was found that the inner cylinder significantly altered the bulk flow field from the solid-body rotation found for a fluid-filled drum. In the counter-rotation case, the generated lift force allowed the cylinder to freely rotate without contact with the drum wall. Drag and lift coefficients of the freely counter-rotating cylinder were measured over a wide range of Reynolds numbers, 2500 < Re < 25000, dimensionless rotation rates, 0.0 < α < 1.2, and gap to cylinder diameter ratios 0.003 < G/2a < 0.5. Drag coefficients were consistent with previous measurements on a cylinder in a uniform flow. However, for the lift coefficient, considerably larger values were observed in the present measurements. We found the enhancement of the lift force to be mainly caused by the vicinity of the wall.

Type
Papers
Copyright
Copyright © Cambridge University Press 2010

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

Ashmore, J., del Pino, C. & Mullin, T. 2005 Cavitation in a lubrication flow between a moving sphere and a boundary. Phys. Rev. Lett. 94, 124501.CrossRefGoogle Scholar
Badr, H. M., Coutanceau, M., Dennis, S. C. R. & Menard, C. 1990 Unsteady flow past a rotating circular cylinder at Reynolds numbers 103 and 104. J. Fluid Mech. 220, 459484.Google Scholar
Bearman, P. W. & Zdravkovich, M. M. 1978 Flow around a circular cylinder near a planar boundary. J. Fluid Mech. 89, 3347.CrossRefGoogle Scholar
Bluemink, J. J., Lohse, D., Prosperetti, A. & van Wijngaarden, L. 2008 A sphere in a uniformly rotating and shear flow. J. Fluid Mech. 600, 201233.Google Scholar
Bluemink, J. J., Lohse, D., Prosperetti, A. & van Wijngaarden, L. 2010 a Drag and lift forces on particles in a rotating flow. J. Fluid Mech. 643, 131.Google Scholar
Bluemink, J. J., Prosperetti, A. & van Wijngaarden, L. 2010 b Hydrodynamic interactions between identical spheres in a solid body rotating flow (unpublished).Google Scholar
Cao, S. & Tamura, Y. 2008 Flow around a circular cylinder in linear shear flows at subscritical Reynolds number. J. Wind Engng Ind. Aerodyn. 96, 19611973.CrossRefGoogle Scholar
Cliffe, K. A. & Tavener, S. J. 2004 The effect of cylinder rotation and blockage ratio on the onset of periodic flows. J. Fluid Mech. 501, 125133.Google Scholar
Clift, R., Grace, J. R. & Weber, M. E. 1978 Bubbles, Drops, and Particles. Dover.Google Scholar
Davis, J. E., Edge, B. L. & Chen, H.-S. 2007 Investigation of unrestrained cylinders rolling in steady uniform flow. Ocean Engng 34, 14311448.CrossRefGoogle Scholar
Goldstein, S. (Ed.) 1965 Modern Developments in Fluid Dynamics, vol. 1. Dover.Google Scholar
Hu, H. H. 1995 Motion of a circular cylinder in a viscous liquid between parallel plates. Theor. Comput. Fluid Dyn. 7, 441455.CrossRefGoogle Scholar
Jeffrey, D. J. & Onishi, Y. 1981 The slow motion of a cylinder near to a plane wall. Q. J. Mech. Appl. Maths 34, 129137.Google Scholar
Jeffrey, G. 1922 The rotation of two circular cylinders in a viscous fluid. Proc. R. Soc. Lond. A 101, 169–74.Google Scholar
Kano, I. & Yagita, M. 2002 Flow around a rotating circular cylinder near a moving plane wall. Japan Soc. Mech. Engng 45, 259268.Google Scholar
Labraga, L., Kahissim, G., Keirsbulck, L. & Beaubert, F. 2007 An experimental investigation of the separation points on a circular rotating cylinder in cross flow. Trans. ASME: J. Fluids Engng 129, 12031211.Google Scholar
Lohse, D. & Prosperetti, A. 2003 Controlling bubbles. J. Phys. Condens. Matter 15, 415420.Google Scholar
Magnaudet, J. & Eames, I. 2000 The motion of high-Reynolds-number bubbles in inhomogeneous flow. Annu. Rev. Fluid Mech. 32, 659708.Google Scholar
Mittal, S. 2003 Flow control using rotating cylinders: effect of gap. Trans. ASME: J. Appl. Mech. 70, 762770.Google Scholar
Mittal, S. & Kumar, B. 2003 Flow past a rotating cylinder. J. Fluid Mech. 476, 303334.CrossRefGoogle Scholar
Naciri, M. A. 1992 Contribution à l'étude des forces exercées par un liquide sur une bulle de gaz: portance, masse ajoutée et interactions hydrodynamiques. PhD thesis, L'Ecole Central de Lyon, France.Google Scholar
van Nierop, E. A., Luther, S., Bluemink, J. J., Magnaudet, J., Prosperetti, A. & Lohse, D. 2007 Drag and lift forces on bubbles in a rotating flow. J. Fluid Mech. 571, 439454.Google Scholar
Nishino, T., Roberts, G. T. & Zhang, X. 2007 Vortex shedding from a circular cylinder near a moving ground. Phys. Fluids 19, 025103.CrossRefGoogle Scholar
Prokunin, A. N. 2003 On a paradox in the motion of a rigid particle along a wall in a fluid. Fluid Dyn. 38, 443457.CrossRefGoogle Scholar
Prokunin, A. N. 2004 Microcavitation in the slow motion of a solid spherical particle along a wall in a fluid. Fluid Dyn. 39, 771778.CrossRefGoogle Scholar
Seddon, J. R. T. & Mullin, T. 2006 Reversal rotation of a cylinder near a wall. Phys. Fluids 18, 041703.CrossRefGoogle Scholar
Stewart, B. E., Hourigan, K., Thompson, M. & Leweke, T. 2006 Flow dynamics and forces associated with a cylinder rolling along a wall. Phys. Fluids 18, 111701.Google Scholar
Stewart, B. E., Thompson, M. C., Leweke, T. & Hourigan, K. 2010 Numerical and experimental studies of the rolling sphere wake. J. Fluid Mech. 643, 137162.Google Scholar
Sumner, D. & Akosile, O. O. 2003 On uniform planar shear flow around a circular cylinder at subcitical Reynolds number. J. Fluids Struct. 18, 441454.Google Scholar
Takayama, S. & Aoki, K. 2004 Flow characteristics around a rotating circular cylinder. Proc. Schl. Engng Tokai Univ. E 29, 914.Google Scholar
Tokumaru, P. T. & Dimotakis, P. E. 1991 Rotary oscillation control of a cylinder wake. J. Fluid Mech. 224, 7790.Google Scholar
Tokumaru, P. T. & Dimotakis, P. E. 1993 The lift of a cylinder executing rotating motions in a uniform flow. J. Fluid Mech. 255, 110.Google Scholar
Yang, L., Seddon, J. R. T., Mullin, T., del Pino, C. & Ashmore, J. 2006 The motion of a rough particle in a Stokes flow adjacent to a boundary. J. Fluid Mech. 557, 337346.Google Scholar
Zdravkovich, M. M. 1985 Forces on a circular cylinder near a plane wall. Appl. Ocean Res. 7, 197201.CrossRefGoogle Scholar

Sun et al. supplementary movie

Movie 1. The movie shows the motion the cylinder (the radius a = 20 mm) in the rotating drum with a rotation frequency $f_{drum}$ = 0.2 Hz. The cylinder co-rotates with the drum.

Download Sun et al. supplementary movie(Video)
Video 477.4 KB

Sun et al. supplementary movie

Movie 2. The movie shows the motion the cylinder (the radius a = 20 mm) in the rotating drum with a rotation frequency $f_{drum}$ = 0.7 Hz. The cylinder counter-rotates with the drum.

Download Sun et al. supplementary movie(Video)
Video 505.2 KB

Sun et al. supplementary movie

Movie 3. The movie shows time evolution of the velocity field around the co-rotating cylinder with radius a = 7.75 mm. The rotating frequency of the drum was set to $f_{drum}$ = 0.15 Hz in this case. The Movie was made by concatenating the consecutively measured instantaneous velocity field of the sampling frequency 50 Hz.

Download Sun et al. supplementary movie(Video)
Video 4.7 MB

Sun et al. supplementary movie

Movie 4. The movie shows time evolution of the velocity field around the counter-rotating cylinder with radius a = 7.75 mm. The rotating frequency of the drum was set to $f_{drum}$ = 0.35 Hz in this case. The Movie was made by concatenating the consecutively measured instantaneous velocity field of the sampling frequency 50 Hz.

Download Sun et al. supplementary movie(Video)
Video 4.7 MB