Hostname: page-component-7c8c6479df-fqc5m Total loading time: 0 Render date: 2024-03-27T11:51:49.749Z Has data issue: false hasContentIssue false

Reduction in greenhouse gas emissions due to the use of bio-ethanol from wheat grain and straw produced in the south-eastern USA

Published online by Cambridge University Press:  28 May 2010

T. PERSSON*
Affiliation:
Department of Biological and Agricultural Engineering, 1109 Experiment Street, The University of Georgia, Griffin, GA 30223, USA
A. GARCIA Y GARCIA
Affiliation:
Department of Biological and Agricultural Engineering, 1109 Experiment Street, The University of Georgia, Griffin, GA 30223, USA
J. O. PAZ
Affiliation:
Department of Biological and Agricultural Engineering, 1109 Experiment Street, The University of Georgia, Griffin, GA 30223, USA
C. W. FRAISSE
Affiliation:
Department of Agricultural and Biological Engineering, 271 Rogers Hall, University of Florida, Gainesville, FL 32611, USA
G. HOOGENBOOM
Affiliation:
Department of Biological and Agricultural Engineering, 1109 Experiment Street, The University of Georgia, Griffin, GA 30223, USA
*
*To whom all correspondence should be addressed. Email: tpersson@uga.edu

Summary

Biofuels can reduce greenhouse gas (GHG) emissions by replacing fossil fuels. However, the energy yield from agronomic crops varies due to local climate, weather and soil variability. A variation in the yield of raw material used (feedstock) could also cause variability in GHG reductions if biofuels are used. The goal of the present study was to determine the net reduction of GHG emissions if ethanol from wheat produced in different regions of the south-eastern USA is used as an alternative to gasoline from fossil fuel sources. Two scenarios were investigated; the first included ethanol produced from grain only, and the second included ethanol produced from both grain and wheat straw. Winter wheat yield was simulated with the Cropping System Model (CSM)-CERES-Wheat model for climate, soil and crop management representing six counties in the following USA states: Alabama, Florida and Georgia. Ethanol production was determined from the simulated grain and straw yields together with fixed grain and straw yield ethanol ratios. Subsequently, net reductions in GHG emissions were determined by accounting for the emissions from the replaced gasoline, and by animal feed and electricity that were replaced by ethanol processing co-products. Greenhouse gases that were emitted in the ethanol production chain were also taken into account. Across all locations, the reduction in GHG emissions was 187 g CO2-equivalents/km in the grain-only scenario and 208 g CO2-equivalents/km in the grain and straw scenario. The reductions in GHG emissions varied significantly between locations and growing seasons within the two scenarios. Similar approaches could be applied to assess the environmental impact of GHG emissions from other biofuels.

Type
Climate Change and Agriculture
Copyright
Copyright © Cambridge University Press 2010

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

Atkinson, M. D., Kettlewell, P. S., Poulton, P. R. & Hollins, P. D. (2008). Grain quality in the Broadbalk Wheat Experiment and the winter North Atlantic Oscillation. Journal of Agricultural Science, Cambridge 146, 541549.CrossRefGoogle Scholar
Bannayan, M., Crout, N. M. J. & Hoogenboom, G. (2003). Application of the CERES-Wheat model for within-season prediction of winter wheat yield in the United Kingdom. Agronomy Journal 95, 114125.Google Scholar
Barbieri, P., Rozas, H. S. & Echeverria, H. E. (2008). Time of nitrogen application affects nitrogen use efficiency of wheat in the humid pampas of Argentina. Canadian Journal of Plant Science 88, 849857.CrossRefGoogle Scholar
Bernesson, S. & Nilsson, D. (2005). Halm som Energikalla. Rapport: Miljo, Teknik och Lantbruk 2005:07. Uppsala, Sweden: Swedish University of Agricultural Sciences.Google Scholar
Bernesson, S., Nilsson, D. & Hansson, P.-A. (2006). A limited LCA comparing large- and small-scale production of ethanol for heavy engines under Swedish conditions. Biomass and Bioenergy 30, 4657.CrossRefGoogle Scholar
Boote, K. J. (1999). Concepts for calibrating crop growth models. In DSSAT version 3, Volume 4 (Eds Hoogenboom, G., Wilkens, P. W. & Tsuji, G. Y.), pp. 179199. Honolulu, HI: University of Hawaii.Google Scholar
Borjesson, P. (2009). Good or bad bioethanol from a greenhouse gas perspective – what determines this? Applied Energy 86, 589594.CrossRefGoogle Scholar
Day, J. L., Coy, A. E. & Rose, P. A. (2001). 2000–2001 Small Grains Performance Tests. Research Report Number 673. Griffin, GA: The University of Georgia.Google Scholar
De Klein, C., Novoa, R. S. A., Ogle, S., Smith, K. A., Rochette, P., Wirth, T. C., McConkey, B. G., Mosier, A. & Rypdal, K. (2006). N2O emissions from managed soils, and CO2 emissions from lime and urea application. In 2006 IPCC Guidelines for National Greenhouse Gas Inventories. Vol. 4. Agriculture, Forestry and Other Land Use (Eds Eggleston, S., Buendia, L., Miwa, K., Ngara, T. & Tanabe, K.), pp. 11·111·54. Geneva, Switzerland: Intergovernmental Panel on Climate Change.Google Scholar
Eckersten, H. & Jansson, P.-E. (1991). Modeling water-flow, nitrogen uptake and production for wheat. Fertilizer Research 27, 313329.CrossRefGoogle Scholar
Eggleston, S., Buendia, L., Miwa, K., Ngara, T. & Tanabe, K. (2006). 2006 Guidelines for National Greenhouse Gas Inventories, Vol. 4 Agriculture, Forestry and Other Land Use. Geneva, Switzerland: Intergovernmental Panel on Climate Change.Google Scholar
Energy Information Administration. (2009). Electric Power Annual with Data for 2007. Washington, DC: Energy Information Administration.Google Scholar
European Bioethanol Fuel Association. (2009). Bioethanol Fuel in the European Union. EBFA Fact Sheet. Brussels: European Bioethanol Fuel Association. Available online at http://ebio.org/downloads/fact_sheets/091116_ethanol_production.pdf (verified 29 April 2010).Google Scholar
Farrell, A. E., Plevin, R. J., Turner, B. T., Jones, A. D., O'Hare, M. & Kammen, D. M. (2006). Ethanol can contribute to energy and environmental goals. Science 311, 506508.CrossRefGoogle ScholarPubMed
Ferguson, R., Lanclos, D., Leonard, B. R., Boquet, D., Hollier, C. & Vidrine, R. (2008). Suggestions for Double-cropping Soybeans and Wheat in Louisiana during 2008. Baton Rouge, LA: Louisiana State University Agricultural Center.Google Scholar
First United Ethanol. (2010). Annual Report under Section 13 or 15(d) of the Securities Exchange Act of 1934. Commission file number 000-53039. Washington, DC: United States Securities and Exchange Commission.Google Scholar
Franzluebbers, A. J. (2005). Soil organic carbon sequestration and agricultural greenhouse gas emissions in the southeastern USA. Soil and Tillage Research 83, 120147.CrossRefGoogle Scholar
Franzluebbers, A. J., Hons, F. M. & Zuberer, D. A. (1998). In situ and potential CO2 evolution from a Fluventic Ustochrept in south central Texas as affected by tillage and cropping intensity. Soil and Tillage Research 47, 303308.CrossRefGoogle Scholar
Gabrielle, B. & Gagnaire, N. (2008). Life-cycle assessment of straw use in bio-ethanol production: a case study based on biophysical modelling. Biomass and Bioenergy 32, 431441.CrossRefGoogle Scholar
Garcia y Garcia, A. & Hoogenboom, G. (2005). Evaluation of an improved daily solar radiation generator for the southeastern USA. Climate Research 29, 91–102.CrossRefGoogle Scholar
Garcia y Garcia, A., Guerra, L. C. & Hoogenboom, G. (2008). Impact of generated solar radiation on simulated crop growth and yield. Ecological Modelling 210, 312326.CrossRefGoogle Scholar
Georgia Automated Environmental Monitoring Network. (2009). http://www.griffin.uga.edu/aemn/ (verified 20 April 2010).Google Scholar
Gillett, A. G., Crout, N. M. J., Stokes, D. T., Sylvester-Bradley, R. & Scott, R. K. (1999). Simple winter wheat green area index model under UK conditions. Journal of Agricultural Science, Cambridge 132, 263271.CrossRefGoogle Scholar
Hay, R. K. M. (1995). Harvest index: a review of its use in plant breeding and crop physiology. Annals of Applied Biology 126, 197216.CrossRefGoogle Scholar
Hill, J., Nelson, E., Tilman, D., Polasky, S. & Tiffany, D. (2006). Environmental, economic, and energetic costs and benefits of biodiesel and ethanol biofuels. Proceedings of the National Academy of Sciences of the United States of America 103, 1120611210.CrossRefGoogle ScholarPubMed
Hodges, T., French, V. & LeDuc, S. K. (1985). Estimating Solar Radiation for Plant Simulation Models. AgRISTARS Technical Report JSC-20239; YM-15-00403. Columbia, MO: NOAA/NESDIS/AISC.Google Scholar
Hoogenboom, G., Jones, J. W., Wilkens, P. W., Porter, C. H., Hunt, L. A., Boote, K. J., Singh, U., Uryasev, O., Lizaso, J. I., White, J. W., Ogoshi, R., Gijsman, A. J., Batchelor, W. D. & Tsuji, G. Y. (2009). Decision Support System for Agrotechnology Transfer Version 4.5 [CD-ROM]. Honolulu, HI: University of Hawaii.Google Scholar
Husky Energy. (2009). Ethanol. Available online at: http://www.huskyenergy.com/ourproducts/canada/ethanol.asp (verified 20 April 2010).Google Scholar
Intergovernmental Panel on Climate Change. (2006). 2006 IPCC Guidelines for National Greenhouse Gas Inventories. Geneva, Switzerland: IPCC.Google Scholar
Iogen Corporation. (2009). Cellulose Ethanol: Clean Fuel for Today and Tomorrow. Ottawa, ON, Canada: Iogen Corporation.Google Scholar
Jamieson, P. D., Semenov, M. A., Brooking, I. R. & Francis, G. S. (1998). Sirius: a mechanistic model of wheat response to environmental variation. European Journal of Agronomy 8, 161179.CrossRefGoogle Scholar
Johnson, J. W., Barnett, R. D., Cunfer, B. M., Buntin, G. D. & Bland, D. E. (2002). Registration of ‘AGS 2000’ wheat. Crop Science 42, 661.CrossRefGoogle Scholar
Langensiepen, M., Hanus, H., Schoop, P. & Grasle, W. (2008). Validating CERES-wheat under North-German environmental conditions. Agricultural Systems 97, 3447.CrossRefGoogle Scholar
Lavigne, A. & Powers, S. E. (2007). Evaluating fuel ethanol feedstocks from energy policy perspectives: A comparative energy assessment of corn and corn stover. Energy Policy 35, 59185930.CrossRefGoogle Scholar
Lee, D., Buntin, D., Culpepper, S., Harris, G., Martinez, A. & Smith, N. (2008). 2008–2009 Wheat Production Guide. CSS-08-10. Griffin, GA, USA: The University of Georgia.Google Scholar
Liska, A. J., Yang, H. S., Bremer, V. R., Klopfenstein, T. J., Walters, D. T., Erickson, G. E. & Cassman, K. G. (2009). Improvements in life cycle energy efficiency and greenhouse gas emissions of corn-ethanol. Journal of Industrial Ecology 13, 5874.CrossRefGoogle Scholar
McNeill, S. & Overhults, D. (2009). Harvesting, drying, and storing wheat. In A Comprehensive Guide to Wheat Management in Kentucky (Eds Bruening, W., Green, J. D., Grove, J., Martin, J. R., Murdock, L., Schwab, G. & Van Sanford, D.), pp. 4750. Lexington, KY: College of Agriculture, University of Kentucky.Google Scholar
Nain, A. S., Dadhwal, V. K. & Singh, T. P. (2004). Use of CERES-Wheat model for wheat yield forecast in central Indo-Gangetic Plains of India. Journal of Agricultural Science, Cambridge 142, 5970.CrossRefGoogle Scholar
Paz, J. O., Fraisse, C. W., Hatch, L. U., Garcia y Garcia, A., Guerra, L. C., Uryasev, O., Bellow, J. G., Jones, J. W. & Hoogenboom, G. (2007). Development of an ENSO-based irrigation decision support tool for peanut production in the southeastern US. Computers and Electronics in Agriculture 55, 2835.CrossRefGoogle Scholar
Persson, T., Garcia y Garcia, A., Paz, J. O., Jones, J. W. & Hoogenboom, G. (2009 a). Maize ethanol feedstock production and net energy value as affected by climate variability and crop management practices. Agricultural Systems 100, 1121.CrossRefGoogle Scholar
Persson, T., Garcia y Garcia, A., Paz, J. O., Jones, J. W. & Hoogenboom, G. (2009 b). Net energy value of maize ethanol as a response to different climate and soil conditions in the southeastern USA. Biomass and Bioenergy 33, 10551064.CrossRefGoogle Scholar
Persson, T., Garcia y Garcia, A., Paz, J. O., Ortiz, B. V. & Hoogenboom, G. (2010). Simulating the production potential and net energy yield of maize-ethanol in the southeastern USA. European Journal of Agronomy 32, 272279.CrossRefGoogle Scholar
Porter, J. R., Jamieson, P. D. & Wilson, D. R. (1993). Comparison of the wheat simulation models AFRCWHEAT2, CERES-Wheat and SWHEAT for nonlimiting conditions of crop growth. Field Crops Research 33, 131157.CrossRefGoogle Scholar
Quirin, M., Gartner, S. O., Pehnt, M., Reinhardt, G. A. (2004). CO2 Mitigation through Biofuels in the Transport Sector. Status and Perspectives. Heidelberg, Germany: Institute for Energy and Environmental Research (IFEU).Google Scholar
Renewable Fuels Association. (2010). The 2010 Ethanol Industry Outlook. Climate of Opportunity. Washington, DC: Renewable Fuels Association.Google Scholar
Rettenmaier, N., Reinhardt, G., Gartner, S. & Von Falkenstein, E. (2008). Greenhouse Gas Balances for VERBIO Ethanol as per the German Biomass Sustainability Ordinance (BioNachV). Final Report. Heidelberg, Germany: Institute for Energy and Environmental Research (IFEU).Google Scholar
Ritchie, J. T., Singh, U., Godwin, D. C. & Bowen, W. T. (1998). Cereal growth, development and yield. In Understanding Options for Agricultural Production (Eds Tsuji, G. Y., Hoogenboom, G. & Thornton, P. K.), pp. 7998. Dordrecht, The Netherlands: Kluwer Academic Publishers.CrossRefGoogle Scholar
Robertson, R. (2008). Four ethanol plants planned for Southeast. Southeast Farm Press 35, 20, 22.Google Scholar
Rose, P. A., Day, J. L., Coy, A. E. & Lee, R. D. (2003). Georgia 2002–2003 Small Grain Performance Tests. Research Report Number 688. Griffin, GA: The University of Georgia.Google Scholar
Rose, P. A., Day, J. L. & Coy, A. E. (2004). Georgia 2003–2004 Small Grain Performance Tests. Research Report Number 694. Griffin, GA: The University of Georgia.Google Scholar
Rose, P. A., Day, J. L. & Coy, A. E. (2005). Georgia 2004–2005 Small Grain Performance Tests. Research Report Number 699. Griffin, GA: The University of Georgia.Google Scholar
SAS Institute Inc. (2002). SAS for Windows. [9.1]. Cary, NC: SAS Institute Inc.Google Scholar
SERCC – The Southeast Regional Climate Center. (2009). Historical Climate Summaries for Georgia. Chapel Hill, NC: Southeast Regional Climate Center. Available online at: http://www.sercc.com/climateinfo/historical/historical_ga.html (verified 21 April 2010).Google Scholar
Sheehan, J., Aden, A., Paustian, K., Killian, K., Brenner, J., Walsh, M. & Nelson, R. (2004). Energy and environmental aspects of using corn stover for fuel ethanol. Journal of Industrial Ecology 7, 117146.CrossRefGoogle Scholar
Silgram, M. & Chambers, B. J. (2002). Effects of long-term straw management and fertilizer nitrogen additions on soil nitrogen supply and crop yields at two sites in eastern England. Journal of Agricultural Science, Cambridge 139, 115127.CrossRefGoogle Scholar
Snyder, C. S., Bruulsema, T. W. & Jensen, T. L. (2007). Greenhouse Gas Emissions from Cropping Systems and the Influence of Fertilizer Management. A Literature Review. Norcross, GA: International Plant Nutrition Institute.Google Scholar
Soil Survey Staff. (2009). National Soil Survey Characterization Data. Lincoln, NE: National Soil Survey Center.Google Scholar
(S&T)2 Consultants Inc. (2003). The Addition of Ethanol from Wheat to GHGenious. Ottawa, ON, Canada: Natural Resources Canada.Google Scholar
Tan, R. R. & Culaba, A. B. (2002). Life Cycle Assessment for Conventional and Alternative Fuels for Road Vehicles. Vashon, Washington, DC: American Center for Life Cycle Assessment.Google Scholar
Thornton, P. K. & Hoogenboom, G. (1994). A computer program to analyze single-season crop model outputs. Agronomy Journal 86, 860868.CrossRefGoogle Scholar
United States Congress. (2007). Energy Independence and Security Act of 2007. Washington, DC: United States Congress.Google Scholar
United States Department of Agriculture: National Agricultural Statistics Service. (2004). 2002 Census of Agriculture. United States, Summary and State Data, Vol. 1. Washington, DC: USDA.Google Scholar
United States Department of Agriculture: National Agricultural Statistics Service. (2009). 2007 Census of Agriculture. United States, Summary and State Data, Vol. 1. Washington, DC: USDA.Google Scholar
United States Department of Agriculture: Soft Wheat Quality Laboratory. (2001). Wheat Variety Database 2000. Wooster, OH: USDA Soft Wheat Quality Laboratory.Google Scholar
United States Department of Energy. (2009). Model Year 2010 Fuel Economy Guide. Washington, DC: US Department of Energy/USEPA.Google Scholar
Vinten, A. J. A., Ball, B. C., O'Sullivan, M. F. & Henshall, J. K. (2002). The effects of cultivation method, fertilizer input and previous sward type on organic C and N storage and gaseous losses under spring and winter barley following long-term leys. Journal of Agricultural Science, Cambridge 139, 231243.CrossRefGoogle Scholar
von Blottnitz, H. & Curran, M. A. (2007). A review of assessments conducted on bio-ethanol as a transportation fuel from a net energy, greenhouse gas, and environmental life cycle perspective. Journal of Cleaner Production 15, 607619.CrossRefGoogle Scholar
Waldron, C., Harnisch, J., Lucon, O., Mckibbon, R. S., Saile, S. B., Wagner, F. & Walsh, M. P. (2006). Mobile combustion. In 2006 IPCC Guidelines for National Greenhouse Gas Inventories. Vol. 2: Energy (Eds Eggleston, S., Buendia, L., Miwa, K., Ngara, T. & Tanabe, K.). Geneva, Switzerland: Intergovernmental Panel on Climate Change.Google Scholar
Wang, M., Saricks, C. & Wu, M. (1997). Fuel-cycle Fossil Energy Use and Greenhouse Gas Emissions of Fuel Ethanol Produced from U. S. Midwest Corn. Argonne, IL: Center for Transportation Research Argonne National Laboratory.CrossRefGoogle Scholar
Wang, M., Wu, M. & Huo, H. (2007). Life-cycle energy and greenhouse gas emission impacts of different corn ethanol plant types. Environmental Research Letters 2, 024001.CrossRefGoogle Scholar
Weir, A. H., Bragg, P. L., Porter, J. R. & Rayner, J. H. (1984). A winter-wheat crop simulation-model without water or nutrient limitations. Journal of Agricultural Science, Cambridge 102, 371382.CrossRefGoogle Scholar
Wilhelm, W. W., Johnson, J. M. F., Hatfield, J. L., Voorhees, W. B. & Linden, D. R. (2004). Crop and soil productivity response to corn residue removal: a literature review. Agronomy Journal 96, 117.Google Scholar
Xiong, W., Conway, D., Holman, I. & Lin, E. (2008). Evaluation of CERES-Wheat simulation of wheat production in China. Agronomy Journal 100, 17201728.CrossRefGoogle Scholar
Zamora, D. S., Jose, S., Jones, J. W. & Cropper, W. P. (2009). Modeling cotton production response to shading in a pecan alleycropping system using CROPGRO. Agroforestry Systems 76, 423435.CrossRefGoogle Scholar