Hostname: page-component-7c8c6479df-r7xzm Total loading time: 0 Render date: 2024-03-29T05:51:04.977Z Has data issue: false hasContentIssue false

Experimental evidence for a short-wave global mode in film flow along periodic corrugations

Published online by Cambridge University Press:  08 February 2013

Z. Cao
Affiliation:
Department of Mechanical Engineering, University of Thessaly, GR-38334 Volos, Greece
M. Vlachogiannis
Affiliation:
Department of Mechanical Engineering, University of Thessaly, GR-38334 Volos, Greece Technological Educational Institute of Larissa, GR-41110 Larissa, Greece
V. Bontozoglou*
Affiliation:
Department of Mechanical Engineering, University of Thessaly, GR-38334 Volos, Greece
*
Email address for correspondence: bont@mie.uth.gr

Abstract

The primary instability of liquid film flow along periodically corrugated substrates is studied experimentally. Two different wall shapes, of the same wavelength and height, are tested for a wide range of inclinations. It is found that, beyond a specific inclination, a new instability mode occurs before the classical, convective, long-wave one. This is a short, travelling wave, which is highly regular and persistently two-dimensional, and appears to be a global mode. The exact shape of the corrugations has a leading-order effect on the inclination at which the new mode appears and on its wavelength at inception. Compared with the behaviour of film flow on a flat substrate, the presently tested periodic walls are found to delay very significantly, but each one to a different extent, the onset of the primary instability. This delay increases with inclination, and presents a distinct discontinuity when transition from the long- to the short-wave mode takes place.

Type
Papers
Copyright
©2013 Cambridge University Press

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

Argyriadi, K., Vlachogiannis, M. & Bontozoglou, V. 2006 Experimental study of inclined film flow along periodic corrugations: the effect of wall steepness. Phys. Fluids 18, 012102.CrossRefGoogle Scholar
Balmforth, N. J. & Liu, J. J. 2004 Roll waves in mud. J. Fluid Mech. 519, 3354.Google Scholar
Bontozoglou, V. & Papapolymerou, G. 1997 Laminar film flow down a wavy incline. Intl J. Multiphase Flow 23, 6979.Google Scholar
Bontozoglou, V. & Serifi, K. 2008 Falling film flow along steep two-dimensional topography: the effect of inertia. Intl J. Multiphase Flow 34, 734747.Google Scholar
Brevdo, L., Laure, P., Dias, F. & Bridges, T. J. 1999 Linear pulse structure and signalling in a film flow on an inclined plane. J. Fluid Mech. 396, 3771.CrossRefGoogle Scholar
Bull, J. L. & Grotberg, J. B. 2003 Surfactant spreading on thin viscous films: Film thickness evolution and periodic wall stretch. Exp. Fluids 34, 115.Google Scholar
Chang, H. C. & Demekhin, E. A. 2002 Complex Wave Dynamics on Thin Films. Elsevier.Google Scholar
Choudhari, M. 1993 Boundary-layer receptivity due to distributed surface imperfections of a deterministic or random nature. Theor. Comput. Fluid Dyn. 4, 101117.Google Scholar
Craster, R. V. & Matar, O. K. 2009 Dynamics and stability of thin liquid films. Rev. Mod. Phys. 81, 11311198.CrossRefGoogle Scholar
D’Alessio, S. J. D., Pascal, J. P. & Jasmine, H. A. 2009 Instability in gravity-driven flow over uneven surfaces. Phys. Fluids 21, 062105.Google Scholar
Dávalos-Orozco, L. A. 2007 Nonlinear instability of a thin film flowing down a smoothly deformed surface. Phys. Fluids 19, 074103.Google Scholar
Davies, A. G. & Heathershaw, A. D. 1984 Surface-wave propagation over sinusoidally varying topography. J. Fluid Mech. 144, 419443.Google Scholar
Duprat, C., Ruyer-Quil, C., Kalliadasis, S. & Giorgiutti-Dauphiné, F. 2007 Absolute and convective instabilities of a viscous film flowing down a vertical fibre. Phys. Rev. Lett. 98, 244502.Google Scholar
Gaskell, P. H., Jimack, P. K., Sellier, M., Thompson, H. M. & Wilson, M. C. T. 2004 Gravity-driven flow of continuous thin liquid films on non-porous substrates with topography. J. Fluid Mech. 509, 253280.CrossRefGoogle Scholar
Georgantaki, A., Vatteville, J., Vlachogiannis, M. & Bontozoglou, V. 2011 Measurements of liquid film flow as a function of fluid properties and channel width: evidence for surface-tension-induced long-range transverse coherence. Phys. Rev. E 84, 026325.Google Scholar
Häcker, T. & Uecker, H. 2009 An integral boundary layer equation for film flow over inclined wavy bottoms. Phys. Fluids 21, 092105.Google Scholar
Heining, C. & Aksel, N. 2009 Bottom reconstruction in thin-film flow over topography: steady solution and linear stability. Phys. Fluids 21, 083605.Google Scholar
Helbig, K., Nasarek, R., Gambaryan-Roisman, T. & Stephan, P. 2009 Effect of longitudinal minigrooves on flow stability and wave characteristics of falling liquid films. J. Heat Transfer 131, 011601.Google Scholar
Huerre, P. & Monkewitz, P. A. 1990 Local and global instabilities in spatially developing flows. Annu. Rev. Fluid Mech. 22, 473537.Google Scholar
Kalliadasis, S. & Homsy, G. M. 2001 Stability of free-surface thin-film flows over topography. J. Fluid Mech. 448, 387410.Google Scholar
Liu, J., Paul, J. D. & Gollub, J. P. 1993 Measurements of the primary instabilities of film flows. J. Fluid Mech. 250, 69101.Google Scholar
Luo, H. & Pozrikidis, C. 2006 Effect of inertia on film flow over oblique and three-dimensional corrugations. Phys. Fluids 18, 078107.Google Scholar
Nguyen, P.-K. & Bontozoglou, V. 2011 Steady solutions of inertial film flow along strongly undulated substrates. Phys. Fluids 23, 052103.Google Scholar
Nguyen, C. C. & Plourde, F. 2011 Wavy wall influence on the hydrodynamic instability of a liquid film flowing along an inclined plane. Intl J. Heat Fluid Flow 32, 698707.Google Scholar
Oron, A., Davis, S. H. & Bankoff, S. G. 1997 Long-scale evolution of thin liquid films. Rev. Mod. Phys. 69, 931980.Google Scholar
Oron, A. & Heining, C. 2008 Weighted-residual integral boundary-layer model for the nonlinear dynamics of thin liquid films falling on an undulating vertical wall. Phys. Fluids 20, 082102.Google Scholar
Pollak, T., Haas, A. & Aksel, N. 2011 Side wall effects on the instability of thin gravity-driven films – from long-wave to short-wave instability. Phys. Fluids 23, 094110.Google Scholar
Pozrikidis, C. 1988 The flow of a liquid film along a periodic wall. J. Fluid Mech. 188, 275300.Google Scholar
Pozrikidis, C. 2003 Effect of surfactants on film flow down a periodic wall. J. Fluid Mech. 496, 105127.CrossRefGoogle Scholar
Quéré, D. 1999 Fluid coating on a fibre. Annu. Rev. Fluid Mech. 31, 347384.Google Scholar
Ruban, A. I. 1984 On the generation of Tollmien-Schlichting waves by sound. Fluid Dyn 19, 709717.Google Scholar
Ruyer-Quil, C. & Manneville, P. 2000 Improved modelling of flows down inclined planes. Eur. Phys. J. B 15, 357369.Google Scholar
de Santos, J. M., Melli, T. R. & Scriven, L. E. 1991 Mechanics of gas–liquid flow in packed-bed contactors. Annu. Rev. Fluid Mech. 23, 233260.Google Scholar
Shetty, S. & Cerro, R. L. 1993 Flow of a thin film over a periodic surface. Intl J. Multiphase Flow 19, 10131027.Google Scholar
Trifonov, Y. Y. 1998 Viscous liquid film flow over a vertical corrugated surface and waves formation on the film free surface. In Third Intl Conf. on Multiphase Flow. Lyon..Google Scholar
Trifonov, Y. Y. 1999 Viscous liquid film flows over a periodic surface. Intl J. Multiphase Flow 24, 11391161.Google Scholar
Trifonov, Y. Y. 2007 Stability of a viscous liquid film flowing down a periodic surface. Intl J. Multiphase Flow 33, 11861204.Google Scholar
Tseluiko, D., Blyth, M. G., Papageorgiou, D. T. & Vanden-Broeck, J.-M. 2008 Effect of an electric field on film flow down a corrugated wall at zero Reynolds number. Phys. Fluids 20, 042103.Google Scholar
Tseluiko, D. & Blyth, M. 2009 Effect of inertia on electrified film flow over a wavy wall. J. Engng Maths 65, 229242.CrossRefGoogle Scholar
Valluri, P., Matar, O. K., Hewitt, G. F. & Mendes, M. A. 2005 Thin film flow over structured packings at moderate reynolds numbers. Chem. Engng Sci. 60, 19651975.Google Scholar
Vlachogiannis, M. & Bontozoglou, V. 2002 Experiments on laminar film flow along a periodic wall. J. Fluid Mech. 457, 133156.Google Scholar
Vlachogiannis, M., Samandas, A., Leontidis, V. & Bontozoglou, V. 2010 Effect of channel width on the primary instability of inclined film flow. Phys. Fluids 22, 012106.Google Scholar
Wang, C.-Y. 1981 Liquid film flowing slowly down a wavy incline. AIChE J. 27, 207212.Google Scholar
Weinstein, S. J. & Ruschak, K. J. 2004 Coating flows. Annu. Rev. Fluid Mech. 36, 2953.Google Scholar
Wierschem, A. & Aksel, N. 2004 Influence of inertia on eddies created in films creeping over strongly undulated substrates. Phys. Fluids 16, 45664574.Google Scholar
Wierschem, A., Bontozoglou, V., Heining, C., Uecker, H. & Aksel, N. 2008 Linear resonance in viscous films on inclined wavy planes. Intl J. Multiphase Flow 34, 580589.Google Scholar
Wierschem, A., Lepski, C. & Aksel, N. 2005 Effect of long undulated bottoms on thin gravity-driven films. Acta Mech. 179, 4166.Google Scholar