Hostname: page-component-76fb5796d-2lccl Total loading time: 0 Render date: 2024-04-26T17:34:51.729Z Has data issue: false hasContentIssue false
  • English
  • Français

Electrophoretic deposition of nanostructured hematite photoanodes for solar hydrogen generation

Published online by Cambridge University Press:  16 February 2016

Xiangyan Chen ,
Meng Wang ,
Jie Chen  and
Shaohua Shen
Xiangyan Chen
Affiliation:
International Research Center for Renewable Energy, State Key Laboratory of Multiphase Flow in Power Engineering, Xi'an Jiaotong University, Xi'an, Shaanxi 710049, China
Meng Wang
Affiliation:
International Research Center for Renewable Energy, State Key Laboratory of Multiphase Flow in Power Engineering, Xi'an Jiaotong University, Xi'an, Shaanxi 710049, China
Jie Chen
Affiliation:
International Research Center for Renewable Energy, State Key Laboratory of Multiphase Flow in Power Engineering, Xi'an Jiaotong University, Xi'an, Shaanxi 710049, China
Shaohua Shen*
Affiliation:
International Research Center for Renewable Energy, State Key Laboratory of Multiphase Flow in Power Engineering, Xi'an Jiaotong University, Xi'an, Shaanxi 710049, China
*
a) Address all correspondence to this author. e-mail: shshen_xjtu@mail.xjtu.edu.cn
Get access

Abstract

In this study, hematite nanoparticles (α-Fe2O3 NPs) were synthesized by hydrothermal method, with morphologies (e.g., nanorhombohedra, nanobars, and nanospheres) facilely tuned by changing the concentrations of glycol in the hydrothermal solution. Then a low-cost and scalable electrophoretic deposition method was used to fabricate nanostructured α-Fe2O3 films as photoanodes for solar hydrogen generation. It was found that the film of α-Fe2O3 nanobars showed the highest photoelectrochemical (PEC) performance compared to those films of α-Fe2O3 nanorhombohedra and nanospheres, with photocurrent density reaching 0.7 mA/cm2 at 0.6 V versus Ag/AgCl. This PEC improvement may be related to the smaller diameters of nanobars shortening the carrier migration distance, reducing the recombination rate of photo-generated carriers. Moreover, all the α-Fe2O3 films showed much higher PEC performances with surface modified by Sn4+, mainly due to the reduced surface charge recombination, as the Sn4+ doped overlayer passivated surface defects. For the film of α-Fe2O3 nanobars, the photocurrent density was increased by 100%, reaching 1.4 mA/cm2 at 0.6 V versus Ag/AgCl.

Keywords

nanostructurephotochemicalenergy generation
Type
Articles
Information
Journal of Materials Research , Volume 31 , Issue 11: Focus Issue: Advanced Materials and Structures for Solar Fuels , 14 June 2016 , pp. 1547 - 1553
Copyright
Copyright © Materials Research Society 2016 

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

Avasare, V., Zhang, Z., Avasare, D., Khan, I., and Qurashi, A.: Room-temperature synthesis of TiO2 nanospheres and their solar driven photoelectrochemical hydrogen production. Int. J. Energy Res. 39, 1714 (2015).Google Scholar
Liu, Y., Li, J., Li, W., Yang, Y., Li, Y., and Chen, Q.: Enhancement of the photoelectrochemical performance of WO3 vertical arrays film for solar water splitting by gadolinium doping. J. Phys. Chem. C 119, 14834 (2015).Google Scholar
Hu, Y., Yan, X., Gu, Y., Chen, X., Bai, Z., Kang, Z., Long, F., and Zhang, Y.: Large-scale patterned ZnO nanorod arrays for efficient photoelectrochemical water splitting. Appl. Surf. Sci. 339, 122 (2015).Google Scholar
Mishra, M. and Chun, D.: α-Fe2O3 as a photocatalytic material: A review. Appl. Catal., A 498, 126 (2015).CrossRefGoogle Scholar
Ohmori, T., Takahashi, H., Mametsuka, H., and Suzuki, E.: Photocatalytic oxygen evolution on α-Fe2O3 films using Fe3+ ion as a sacrificial oxidizing agent. Phys. Chem. Chem. Phys. 2, 3519 (2000).Google Scholar
Glasscock, J.A., Barnes, P.R.F., Plumb, I.C., Bendavid, A., and Martin, P.J.: Structural, optical and electrical properties of undoped polycrystalline hematite thin films produced using filtered arc deposition. Thin Solid Films 516, 1716 (2008).Google Scholar
Qi, X., She, G., Wang, M., Mu, L., and Shi, W.: Electrochemical synthesis of p-type Zn-doped α-Fe2O3 nanotube arrays for photoelectrochemical water splitting. Chem. Commun. 49, 5742 (2013).CrossRefGoogle ScholarPubMed
Rioult, M., Belkhou, R., Magnan, H., Stanescu, D., Stanescu, S., Maccherozzi, F., Rountree, C., and Barbier, A.: Local electronic structure and photoelectrochemical activity of partial chemically etched Ti-doped hematite. Surf. Sci. 641, 310 (2015).Google Scholar
Ling, Y. and Li, Y.: Review of Sn-doped hematite nanostructures for photoelectrochemical water splitting. Part. Part. Syst. Charact. 31, 1113 (2014).Google Scholar
Kumari, S., Singh, A.P., Sonal, , Deva, D., Shrivastav, R., Dass, S., and Satsangi, V.R.: Spray pyrolytically deposited nanoporous Ti4+ doped hematite thin films for efficient photoelectrochemical splitting of water. Int. J. Hydrogen Energy 35, 3985 (2010).CrossRefGoogle Scholar
Glasscock, J.A., Barnes, P.R.F., Plumb, I.C., and Savvides, N.: Enhancement of photoelectrochemical hydrogen production from hematite thin films by the introduction of Ti and Si. J. Phys. Chem. C 111, 16477 (2007).Google Scholar
Zhong, D.K., Sun, J., Inumaru, H., and Gamelin, D.R.: Solar water oxidation by composite catalyst/α-Fe2O3 photoanodes. J. Am. Chem. Soc. 131, 6086 (2009).Google Scholar
Li, X., Wang, Z., Zhang, Z., Chen, L., Cheng, J., Ni, W., Wang, B., and Xie, E.: Light illuminated α-Fe2O3/Pt nanoparticles as water activation agent for photoelectrochemical water splitting. Sci. Rep. 5, 9130 (2015).Google Scholar
Ling, Y., Wang, G., Wang, H., Yang, Y., and Li, Y.: Low-temperature activation of hematite nanowires for photoelectrochemical water oxidation. ChemSusChem 7, 848 (2014).Google Scholar
Shen, S., Li, M., Guo, L., Jiang, J., and Mao, S.S.: Surface passivation of undoped hematite nanorod arrays via aqueous solution growth for improved photoelectrochemical water splitting. J. Colloid Interface Sci. 427, 20 (2014).Google Scholar
Shen, S.: Toward efficient solar water splitting over hematite photoelectrodes. J. Mater. Res. 29, 29 (2014).Google Scholar
Lindgren, T., Wang, H.L., Beermann, N., Vayssieres, L., Hagfeldt, A., and Lindquist, S.E.: Aqueous photoelectrochemistry of hematite nanorod array. Sol. Energy Mater. Sol. Cells 71, 231 (2002).Google Scholar
Mao, A., Han, G.Y., and Park, J.H.: Synthesis and photoelectrochemical cell properties of vertically grown alpha-Fe2O3 nanorod arrays on a gold nanorod substrate. J. Mater. Chem. 20, 2247 (2010).CrossRefGoogle Scholar
Vayssieres, L., Beermann, N., Lindquist, S.E., and Hagfeldt, A.: Controlled aqueous chemical growth of oriented three-dimensional crystalline nanorod arrays: Application to iron(III) oxides. Chem. Mater. 13, 233 (2001).Google Scholar
Klahr, B.M., Martinson, A.B.F., and Hamann, T.W.: Photoelectrochemical investigation of ultrathin film iron oxide solar cells prepared by atomic layer deposition. Langmuir 27, 461 (2011).Google Scholar
Liang, L. and Koshizaki, N.: Vertically aligned and ordered hematite hierarchical columnar arrays for applications in field-emission, superhydrophilicity, and photocatalysis. J. Mater. Chem. 20, 2972 (2010).Google Scholar
Enache, C.S., Liang, Y.Q., and van de Krol, R.: Characterization of structured α-Fe2O3 photoanodes prepared via electrodeposition and thermal oxidation of iron. Thin Solid Films 520, 1034 (2011).Google Scholar
Zong, X., Thaweesak, S., Xu, H., Xing, Z., Zou, J., Lu, G.M., and Wang, L.: A scalable colloidal approach to prepare hematite films for efficient solar water splitting. Phys. Chem. Chem. Phys. 15, 12314 (2013).Google Scholar
Yanyan, X., Guoying, Z., Guixiang, D., Yaqiu, S., and Dongzhao, G.: α-Fe2O3 nanostructures with different morphologies: Additive-free synthesis, magnetic properties, and visible light photocatalytic properties. Mater. Lett. 92, 321 (2013).Google Scholar
Wang, G., Yang, X., Qian, F., Zhang, J.Z., and Li, Y.: Double-sided CdS and CdSe quantum dot Co-sensitized ZnO nanowire arrays for photoelectrochemical hydrogen generation. Nano Lett. 10, 1088 (2010).Google Scholar
Yang, X., Wolcott, A., Wang, G., Sobo, A., Fitzmorris, R.C., Qian, F., Zhang, J.Z., and Li, Y.: Nitrogen-doped ZnO nanowire arrays for photoelectrochemical water splitting. Nano Lett. 9, 455 (2009).Google Scholar
Wang, G., Wang, H., Ling, Y., Tang, Y., Yang, X., Fitzmorris, R.C., Wang, C., Zhang, J.Z., and Li, Y.: Hydrogen-treated TiO2 nanowire arrays for photoelectrochemical water splitting. Nano Lett. 11, 3026 (2011).CrossRefGoogle ScholarPubMed
Kennedy, J.H. and Frese, J.K.W.: Photooxidation of water at α-Fe2O3 electrodes. Electrochem. Soc. 125, 709 (1978).Google Scholar
Liu, R., Zheng, Z., Spurgeon, J., and Yang, X.: Enhanced photoelectrochemical water-splitting performance of semiconductors by surface passivation layers. Energy Environ. Sci. 7, 2504 (2014).Google Scholar
Franking, R., Li, L., Lukowski, M.A., Meng, F., Tan, Y., Hamers, R.J., and Jin, S.: Facile post-growth doping of nanostructured hematite photoanodes for enhanced photoelectrochemical water oxidation. Energy Environ. Sci. 6, 500 (2013).Google Scholar
Xi, L., Chiam, S.Y., Mak, W.F., Tran, P.D., Barber, J., Loo, S.C.J., and Wong, L.H.: A novel strategy for surface treatment on hematite photoanode for efficient water oxidation. Chem. Sci. 4, 164 (2013).Google Scholar
Ruan, G., Wu, S., Wang, P., Liu, J., Cai, Y., Tian, Z., Ye, Y., Liang, C., and Shao, G.: Simultaneous doping and growth of Sn-doped hematite nanocrystalline films with improved photoelectrochemical performance. RSC Adv. 4, 63408 (2014).Google Scholar
Supplementary material: File

Chen supplementary material S1

Revised Supplementary Material

Download Chen supplementary material S1(File)
File 3.7 MB