Hostname: page-component-8448b6f56d-sxzjt Total loading time: 0 Render date: 2024-04-24T08:06:17.064Z Has data issue: false hasContentIssue false

Studies of Corrosion of Al Thin Films using Liquid Cell Transmission Electron Microscopy

Published online by Cambridge University Press:  29 April 2013

See Wee Chee
Affiliation:
Department of Materials Science and Engineering, Rensselaer Polytechnic Institute, Troy, NY 12180, U.S.A.
Frances M. Ross
Affiliation:
IBM T. J. Watson Research Center, Yorktown Heights, NY 10598, U.S.A.
David Duquette
Affiliation:
Department of Materials Science and Engineering, Rensselaer Polytechnic Institute, Troy, NY 12180, U.S.A.
Robert Hull
Affiliation:
Department of Materials Science and Engineering, Rensselaer Polytechnic Institute, Troy, NY 12180, U.S.A.
Get access

Abstract

A fundamental understanding of the processes that occur during early stages of corrosion is traditionally limited by the dearth of techniques that probe the liquid-solid interface with both high spatial resolution and microstructural detail such as grain size and orientation. Here, we demonstrate that with a microfluidic liquid flow cell holder, we can track the progress of corrosion in situ in Al thin films with transmission electron microscopy (TEM). To mitigate the loss of resolution caused by imaging through liquid, we developed a method in which the liquid is temporarily de-wetted from the entire windowed area by switching the liquid stream from pure water to a mixture of ethanol and water. In the de-wetted region, we then collected images of the film microstructure with high spatial resolution over regular intervals while maintaining a low electron flux over the imaged area to minimize beam-induced effects. For as-deposited films, we find that the corrosion progresses in a fractal manner, consistent with reported behavior for films studied in water with low iron and chloride concentrations. For films that were subjected to rapid thermal annealing, we observe a higher density of pitting events, which we attribute to defects created by thermal stress in the oxide film. Furthermore, we observe that the pits can form at multiple locations in a single grain and are not confined to grain boundaries.

Type
Articles
Copyright
Copyright © Materials Research Society 2013

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

Frankel, G.S., J. Electrochem. Soc. 145, 2186 (1998).10.1149/1.1838615CrossRefGoogle Scholar
de Jonge, N. and Ross, F.M., Nat. Nanotechnol. 6, 695 (2011).10.1038/nnano.2011.161CrossRefGoogle Scholar
Zheng, H., Smith, R.K., Jun, Y.-W., Kisielowski, C., Dahmen, U. and Alivisatos, A.P., Science 324, 1309 (2009).10.1126/science.1172104CrossRefGoogle Scholar
Zheng, H., Claridge, S.A., Minor, A.M., Alivisatos, A.P., and Dahmen, U., Nano Lett. 9, 2460 (2009).10.1021/nl9012369CrossRefGoogle Scholar
Williamson, M.J., Tromp, R.M., Vereecken, P.M., Hull, R. and Ross, F.M., Nat. Mater. 2, 532 (2003).10.1038/nmat944CrossRefGoogle Scholar
Klein, K.L., Anderson, I.M., and de Jonge, N., J. Microsc. 242, 117 (2011).10.1111/j.1365-2818.2010.03484.xCrossRefGoogle Scholar
Noh, K.W., Liu, Y., Sun, L. and Dillon, S.J., Ultramicroscopy 116, 34 (2012)10.1016/j.ultramic.2012.03.012CrossRefGoogle Scholar
White, E.R., Mecklenburg, M., Shevitski, B., Singer, S.B. and Regan, B.C., Langmuir 28, 3695 (2012)10.1021/la2048486CrossRefGoogle Scholar
Woehl, T.J., Jungjohann, K.L., Evans, J.E., Arslan, I., Ristenpart, W.D. and Browning, N.D., Ultramicroscopy, in press, http://dx.doi.org/10.1016/j.ultramic.2012.07.018, (2012).CrossRefGoogle Scholar
Balazs, L. and Gouyet, J., Physica A 217, 319 (1995)CrossRefGoogle Scholar
Proost, J., Baklanov, M. and Verbeeck, R., J. Solid State Electrochem. 2, 150 (1998)10.1007/s100080050080CrossRefGoogle Scholar
Smith, U., Kristensen, N., Ericson, F. and Schweitz, J.-Å., J. Vac. Sci. Technol. A 9, 2527 (1991)CrossRefGoogle Scholar
Hernandez, S., Griffin, A.J. Jr., Brotzen, F.R. and Dunn, C.F., J. Electrochem. Soc. 142, 1215 (1995)10.1149/1.2044154CrossRefGoogle Scholar
Szklarska-Smialowska, Z., Corros. Sci. 41, 17431767 (1999)10.1016/S0010-938X(99)00012-8CrossRefGoogle Scholar